Anaerobic conversion of the hydrothermal liquefaction aqueous phase: Fate of organics and intensification with granule activated carbon/ozone pretreatment

Buchun Si, Libin Yang, Xuefei Zhou, Jamison Watson, Giovana Tommaso, Wan Ting Chen, Qiang Liao, Na Duan, Zhidan Liu, Yuanhui Zhang

Research output: Contribution to journalArticle

Abstract

Hydrothermal liquefaction (HTL) is considered to be a promising route for biofuel production from wet biomass. Transportation fuels and chemicals can be accessed through this process. However, a high strength aqueous phase is also produced during HTL. The conversion of the aqueous phase could significantly contribute to energy and nutrient recovery. Anaerobic fermentation has recently been proposed to biologically convert the HTL aqueous phase into biomethane. However, only a limited amount of information about the fate of the HTL aqueous phase and its conversion during anaerobic conversion is available, and it suffers from a few setbacks, including a low degradation efficiency of organics (33-64% COD) and high dilution rates (5-1000). Herein, the fates and conversion of organics in the HTL aqueous phase during anaerobic conversion were investigated by matrix-assisted laser desorption/ionization time of flight mass spectrometry (MALDI-TOF-MS), gas chromatography-mass spectrometry (GC-MS) and high performance liquid chromatography (HPLC). MALDI-TOF-MS analysis combined with organics/nitrogen balance indicated that the remaining organics (over 30%) after anaerobic conversion might come from nitrogen-containing polymers (over 1000 Da). These nitrogen-containing polymers tended to be converted into oligomers and led to a decrease in the molecular weight (100-300 Da) by anaerobic microbes but could not be further converted into methane. Organic acids and potential inhibitors (N-heterocycles and aromatic compounds) could be completely converted into methane, but the acetogenesis of anaerobic fermentation was inhibited with an increased fermentation concentration. Ozone pretreatment and granule activated carbon (GAC) addition were integrated to improve the anaerobic conversion efficiency of the HTL aqueous phase. Ozone pretreatment significantly improved the conversion of organics and methane production by 109% through converting the inhibitors. At the same time, ozone pretreatment could convert nitrogen-containing polymers into low molecular weight organics, but organics with a molecular weight ranging from 500 to 1000 Da were produced and could not be converted by microbes or adsorbed by GAC. In comparison, GAC addition increased the methane yield more remarkably by 298% at a 2× dilution rate of the HTL aqueous phase through adsorbing inhibitors and enriching robust microbes, such as detoxification bacteria and syntrophic acetogens. Moreover, GAC adsorbed the recalcitrant organics and resulted in a removal of organics of 93.3-96.8%. Therefore, clean water with polished nutrients could be achieved through intensified anaerobic conversion, which could enhance the following biomass production and nutrient recovery through algae cultivation.

Original languageEnglish (US)
Pages (from-to)1305-1318
Number of pages14
JournalGreen Chemistry
Volume21
Issue number6
DOIs
StatePublished - Jan 1 2019

Fingerprint

Ozone
Liquefaction
liquefaction
Activated carbon
activated carbon
ozone
Methane
Nitrogen
methane
Fermentation
Nutrients
fermentation
Mass spectrometry
inhibitor
Polymers
polymer
mass spectrometry
Molecular weight
Dilution
Ionization

ASJC Scopus subject areas

  • Environmental Chemistry
  • Pollution

Cite this

Anaerobic conversion of the hydrothermal liquefaction aqueous phase : Fate of organics and intensification with granule activated carbon/ozone pretreatment. / Si, Buchun; Yang, Libin; Zhou, Xuefei; Watson, Jamison; Tommaso, Giovana; Chen, Wan Ting; Liao, Qiang; Duan, Na; Liu, Zhidan; Zhang, Yuanhui.

In: Green Chemistry, Vol. 21, No. 6, 01.01.2019, p. 1305-1318.

Research output: Contribution to journalArticle

Si, Buchun ; Yang, Libin ; Zhou, Xuefei ; Watson, Jamison ; Tommaso, Giovana ; Chen, Wan Ting ; Liao, Qiang ; Duan, Na ; Liu, Zhidan ; Zhang, Yuanhui. / Anaerobic conversion of the hydrothermal liquefaction aqueous phase : Fate of organics and intensification with granule activated carbon/ozone pretreatment. In: Green Chemistry. 2019 ; Vol. 21, No. 6. pp. 1305-1318.
@article{0c785bdd0ca54f86a6d269f971b8ee1c,
title = "Anaerobic conversion of the hydrothermal liquefaction aqueous phase: Fate of organics and intensification with granule activated carbon/ozone pretreatment",
abstract = "Hydrothermal liquefaction (HTL) is considered to be a promising route for biofuel production from wet biomass. Transportation fuels and chemicals can be accessed through this process. However, a high strength aqueous phase is also produced during HTL. The conversion of the aqueous phase could significantly contribute to energy and nutrient recovery. Anaerobic fermentation has recently been proposed to biologically convert the HTL aqueous phase into biomethane. However, only a limited amount of information about the fate of the HTL aqueous phase and its conversion during anaerobic conversion is available, and it suffers from a few setbacks, including a low degradation efficiency of organics (33-64{\%} COD) and high dilution rates (5-1000). Herein, the fates and conversion of organics in the HTL aqueous phase during anaerobic conversion were investigated by matrix-assisted laser desorption/ionization time of flight mass spectrometry (MALDI-TOF-MS), gas chromatography-mass spectrometry (GC-MS) and high performance liquid chromatography (HPLC). MALDI-TOF-MS analysis combined with organics/nitrogen balance indicated that the remaining organics (over 30{\%}) after anaerobic conversion might come from nitrogen-containing polymers (over 1000 Da). These nitrogen-containing polymers tended to be converted into oligomers and led to a decrease in the molecular weight (100-300 Da) by anaerobic microbes but could not be further converted into methane. Organic acids and potential inhibitors (N-heterocycles and aromatic compounds) could be completely converted into methane, but the acetogenesis of anaerobic fermentation was inhibited with an increased fermentation concentration. Ozone pretreatment and granule activated carbon (GAC) addition were integrated to improve the anaerobic conversion efficiency of the HTL aqueous phase. Ozone pretreatment significantly improved the conversion of organics and methane production by 109{\%} through converting the inhibitors. At the same time, ozone pretreatment could convert nitrogen-containing polymers into low molecular weight organics, but organics with a molecular weight ranging from 500 to 1000 Da were produced and could not be converted by microbes or adsorbed by GAC. In comparison, GAC addition increased the methane yield more remarkably by 298{\%} at a 2× dilution rate of the HTL aqueous phase through adsorbing inhibitors and enriching robust microbes, such as detoxification bacteria and syntrophic acetogens. Moreover, GAC adsorbed the recalcitrant organics and resulted in a removal of organics of 93.3-96.8{\%}. Therefore, clean water with polished nutrients could be achieved through intensified anaerobic conversion, which could enhance the following biomass production and nutrient recovery through algae cultivation.",
author = "Buchun Si and Libin Yang and Xuefei Zhou and Jamison Watson and Giovana Tommaso and Chen, {Wan Ting} and Qiang Liao and Na Duan and Zhidan Liu and Yuanhui Zhang",
year = "2019",
month = "1",
day = "1",
doi = "10.1039/c8gc02907e",
language = "English (US)",
volume = "21",
pages = "1305--1318",
journal = "Green Chemistry",
issn = "1463-9262",
publisher = "Royal Society of Chemistry",
number = "6",

}

TY - JOUR

T1 - Anaerobic conversion of the hydrothermal liquefaction aqueous phase

T2 - Fate of organics and intensification with granule activated carbon/ozone pretreatment

AU - Si, Buchun

AU - Yang, Libin

AU - Zhou, Xuefei

AU - Watson, Jamison

AU - Tommaso, Giovana

AU - Chen, Wan Ting

AU - Liao, Qiang

AU - Duan, Na

AU - Liu, Zhidan

AU - Zhang, Yuanhui

PY - 2019/1/1

Y1 - 2019/1/1

N2 - Hydrothermal liquefaction (HTL) is considered to be a promising route for biofuel production from wet biomass. Transportation fuels and chemicals can be accessed through this process. However, a high strength aqueous phase is also produced during HTL. The conversion of the aqueous phase could significantly contribute to energy and nutrient recovery. Anaerobic fermentation has recently been proposed to biologically convert the HTL aqueous phase into biomethane. However, only a limited amount of information about the fate of the HTL aqueous phase and its conversion during anaerobic conversion is available, and it suffers from a few setbacks, including a low degradation efficiency of organics (33-64% COD) and high dilution rates (5-1000). Herein, the fates and conversion of organics in the HTL aqueous phase during anaerobic conversion were investigated by matrix-assisted laser desorption/ionization time of flight mass spectrometry (MALDI-TOF-MS), gas chromatography-mass spectrometry (GC-MS) and high performance liquid chromatography (HPLC). MALDI-TOF-MS analysis combined with organics/nitrogen balance indicated that the remaining organics (over 30%) after anaerobic conversion might come from nitrogen-containing polymers (over 1000 Da). These nitrogen-containing polymers tended to be converted into oligomers and led to a decrease in the molecular weight (100-300 Da) by anaerobic microbes but could not be further converted into methane. Organic acids and potential inhibitors (N-heterocycles and aromatic compounds) could be completely converted into methane, but the acetogenesis of anaerobic fermentation was inhibited with an increased fermentation concentration. Ozone pretreatment and granule activated carbon (GAC) addition were integrated to improve the anaerobic conversion efficiency of the HTL aqueous phase. Ozone pretreatment significantly improved the conversion of organics and methane production by 109% through converting the inhibitors. At the same time, ozone pretreatment could convert nitrogen-containing polymers into low molecular weight organics, but organics with a molecular weight ranging from 500 to 1000 Da were produced and could not be converted by microbes or adsorbed by GAC. In comparison, GAC addition increased the methane yield more remarkably by 298% at a 2× dilution rate of the HTL aqueous phase through adsorbing inhibitors and enriching robust microbes, such as detoxification bacteria and syntrophic acetogens. Moreover, GAC adsorbed the recalcitrant organics and resulted in a removal of organics of 93.3-96.8%. Therefore, clean water with polished nutrients could be achieved through intensified anaerobic conversion, which could enhance the following biomass production and nutrient recovery through algae cultivation.

AB - Hydrothermal liquefaction (HTL) is considered to be a promising route for biofuel production from wet biomass. Transportation fuels and chemicals can be accessed through this process. However, a high strength aqueous phase is also produced during HTL. The conversion of the aqueous phase could significantly contribute to energy and nutrient recovery. Anaerobic fermentation has recently been proposed to biologically convert the HTL aqueous phase into biomethane. However, only a limited amount of information about the fate of the HTL aqueous phase and its conversion during anaerobic conversion is available, and it suffers from a few setbacks, including a low degradation efficiency of organics (33-64% COD) and high dilution rates (5-1000). Herein, the fates and conversion of organics in the HTL aqueous phase during anaerobic conversion were investigated by matrix-assisted laser desorption/ionization time of flight mass spectrometry (MALDI-TOF-MS), gas chromatography-mass spectrometry (GC-MS) and high performance liquid chromatography (HPLC). MALDI-TOF-MS analysis combined with organics/nitrogen balance indicated that the remaining organics (over 30%) after anaerobic conversion might come from nitrogen-containing polymers (over 1000 Da). These nitrogen-containing polymers tended to be converted into oligomers and led to a decrease in the molecular weight (100-300 Da) by anaerobic microbes but could not be further converted into methane. Organic acids and potential inhibitors (N-heterocycles and aromatic compounds) could be completely converted into methane, but the acetogenesis of anaerobic fermentation was inhibited with an increased fermentation concentration. Ozone pretreatment and granule activated carbon (GAC) addition were integrated to improve the anaerobic conversion efficiency of the HTL aqueous phase. Ozone pretreatment significantly improved the conversion of organics and methane production by 109% through converting the inhibitors. At the same time, ozone pretreatment could convert nitrogen-containing polymers into low molecular weight organics, but organics with a molecular weight ranging from 500 to 1000 Da were produced and could not be converted by microbes or adsorbed by GAC. In comparison, GAC addition increased the methane yield more remarkably by 298% at a 2× dilution rate of the HTL aqueous phase through adsorbing inhibitors and enriching robust microbes, such as detoxification bacteria and syntrophic acetogens. Moreover, GAC adsorbed the recalcitrant organics and resulted in a removal of organics of 93.3-96.8%. Therefore, clean water with polished nutrients could be achieved through intensified anaerobic conversion, which could enhance the following biomass production and nutrient recovery through algae cultivation.

UR - http://www.scopus.com/inward/record.url?scp=85060846679&partnerID=8YFLogxK

UR - http://www.scopus.com/inward/citedby.url?scp=85060846679&partnerID=8YFLogxK

U2 - 10.1039/c8gc02907e

DO - 10.1039/c8gc02907e

M3 - Article

AN - SCOPUS:85060846679

VL - 21

SP - 1305

EP - 1318

JO - Green Chemistry

JF - Green Chemistry

SN - 1463-9262

IS - 6

ER -